Ztrem Motorsports
Economics of Synthetics vs. Petroleum Lubricants
All of the manufacturers of synthetic oil tout the benefits of reduced wear, more horsepower, lower operating temperatures, and improved fuel mileage. All of these benefits are derivatives of better cold flow characteristics and higher levels of friction reducing additives that are found in synthetic oils. I can confirm better cold driving characteristics, increased fuel mileage of nearly 10%, noticeably lower operating temperatures, better heat dissipation capability, and long term high temperature stability based on my own experience with synthetic lubricants. Are these benefits enough, however, to persuade average drivers to give up their trusted petroleum oils and pay the extra price for synthetics? Enthusiasts, yes. Average drivers, perhaps not. However, synthetic lubricants can endure extended drain intervals, which is a major consideration toward justification of the higher costs. This benefit is not widely promoted by the major oil producers most likely because they want you to pay a premium for their synthetic oils every 3000 miles just like their regular oils. Most companies don't bother to tell you that synthetic oils are capable of going 25,000 miles or more without significant breakdown. One customer told me he drove his Toyota more than 50000 miles (with filter changes every 10000 miles) before oil analysis results told him it was time for a change. It is not uncommon for over the road truckers to go several hundred thousand miles between synthetic oil changes but it should also be noted that most are equipped with finer oil filtration devices than most passenger cars. The short trips and stop and go city driving that most of do is much tougher on motor oil than over the road highway driving. In fact, frequent short trips (2 miles or less) and stop and go city driving is considered by some raters as extreme and our cars need increased protection. Fortunately, we can achieve the superior protection and the economic benefits of synthetic oils while staying within the recommendations of our car manufacturers.
Consider the following economic argument. If you change your oil every 3000 miles at a quick lube center at an average price of $23.00 per change, you spend $115.00 over 15000 miles. Most synthetic oil changes cost about $50.00 (much less if you do it yourself) on which you can drive 7500 miles very safely (a 7500 mile interval is within virtually all manufacturers recommendations). Over the same 15000 miles, only two oil changes are required for an investment of $100.00. A shop could charge up to $57.50 and it is still a break-even proposition, plus you put a superior product in your car and are receiving the additional benefits that synthetic lubricants can provide. I typically drive about 12000 miles between changes with a filter change and oil analysis at 6000. Even after 12000 miles oil analysis advises that the oil is "suitable for continued use" and typically the wear metals are less than conventional oil after 3000 miles. In fact in a test performed by Popular Mechanics some years ago, oil analysis showed in New York City taxicabs that there is typically less oil breakdown and less wear metals in Amsoil 10W40 synthetic oil after 60000 miles (albeit with filter changes every 6000 miles) vs. conventional 10W40 oil after 3000 miles. As an added benefit, less waste oil is being put back into the environment. A true win-win proposition.
Conclusion
Most major brand name petroleum oils perform adequately provided your driving conditions are normal and provided you change the oil regularly (remember, short city trips, driver's ed track events, dusty conditions, and towing are considered extreme). Over the counter additives have been proven to be of little to no benefit, often do more harm than good, and are a waste of money regardless of what you drive and how you drive it. Finally, for those of you who drive your vehicle hard, tow a trailer, drive very short distances, sit idling and in stop & go traffic for long periods, live in a cold climate and/or if your car runs hot, quality synthetic motor oil, synthetic gear lube, and synthetic automatic transmission fluid is a wise investment that will provide the additional protection you require as well as last thousands of miles longer than conventional lubricants.
Don Stevens is a mechanical engineering graduate of the Ohio State University and has been a member of the Suncoast Region of the PCA and BMWCCA for 14 years. He is also a 10-year veteran road racer/driving instructor with hundreds of hours of seat time and several endurance race wins to his credit. For more information on lubricants, oil analysis or for a free catalog on the complete line of Amsoil products, please call or e-mail us at amsoil@earthlink.net or call 1-661-296-7188
Ztrem Motorsports
