(07 - 19 - 03) $0215.47 Sent radiator in for a re-core. before I drive again I need to buy radiator coolant, new thermostat (old one is melted), new hoses, a gasket for the hose-spout on top of the intake manifold, and do a transmission fluid change.
(05 - 25 - 03) $0004.78 Wooden facia piece around the center clock and four push-buttons was cracking and pealing. A never-to-be-again-passenger poked at it making a large chunk of wood snap and fall off. I took a utility knife and got rid of all the remaining wood, then used course grain sand-paper to get rid of glue, wood bits, and areas of red crust. Once the metal was all silver, I used fine sand-paper, and smothed the whole piece out. After that I spray-painted the bare facia gloss-black. Let dry, and reinstalled.
Old Facia New Facia
(05 - 18 - 03) $0002.19 Installed new 1/2" heater hose. Old one formed a crack in it at the radiator-side connection. Self-install.
(05 - 10 - 03) $0000.00 Picked up tires, shop did complimentary tire installation. Sears Autimotive Center.
(03 - 21 - 03) $0291.65 One set of Pirelli P4000 tires bought. Sears Autimotive Center.
(01 - 18 - 03) $0062.52 New starter installed. Self-install
(01 - 14 - 03) $0030.02 Oil change, five quarts synthetic blend, new oil filter. Car wouldn't start at service station like normal, mechanic jacks car up, then hits the starter with a mallot. The car starts. The car has a bad starter. Service station.
(12 - 19 - 02) $0201.31 Taillight lenses both left and right side are bought and installed, lense to lamp gaskets included. Horn relay bought and installed to replace 12 - 12 - 02 relay swap. Self-install.
(12 - 12 - 02) $0000.00 Located, and removed old horn relay, replaced with "fan control" relay, horn now works. Self-install.
(10 - 18 - 02) $0125.00 New chevy serpentine belt installed. The newly installed belt was sold with the car when selling owner found out from the purchasing inspection that the car's belt was worn. New chevy 105 Amp alternator bought. Old alternator's bearings went out, and the spindle rattled around freely as it spun. Self-install.
(04 - 23 - 02) $0037.20 Spedometer cable connector bought, located, and replaced, to fix the not working spedometer. Self-install.
(10 - 26 - 01) $0533.08 Front brake rotors resurfaced at service station, replaced front brake pads, inspected calipers, brake lines, master cylinder, and fluid levels. Installed two new Pirelli tires on the rear. Preformed front-end alignment.
(08 - 02 - 01) $0048.20 Passed smog inspection with new EGR valve installed at service station.
(07 - 31 - 01) $0099.47 Bought, and installed new EGR valve as per the reccomendation of the smog inspector. Self-install.
(07 - 30 - 01) $0011.33 Removed, and replaced valve cover gaskets. Old cork & glue type was found, and taken off in a solvent tank. New glueless rubber gaskets installed. Self-install.
(07 - 27 - 01) $0048.20 Failed smog inspection at service station, told it was the fault of a bad EGR valve. Service station.
(05 - 22 - 01) $0158.43 Front, and Rear brake work. Replaced rear brake shoes, adjusted parking brake, and added DOT 4 fluid. Service station
(05 - 20 - 01) $3995.00 XJS was bought from previous owner. Spedometer worked, valve cover gaskets leaked, air conditioner didn't work, alternator worked fine with no whine or rattling, rubber caulking installed around rear window and front windshield, brand new tires, 125,000 miles on car, 20,000 miles on new chevy engine, new rack, driver's side window worked, paint somewhat oxidized, and stitching in the leather upholstry unstiching in a couple spots in the front seats, rear seats were fine.
(05 - 19 - 01) $0130.00 Purchasing inspection at service station. Needed Valve cover gaskets, Serpentine belt, needs front and rear brake pads replaced.
Horn, Robert
(01 - 19 - 01) $0000.00 Service station - Check spedometer cable, it doesn't work. Install 50 amp fuse for Air Conditioning motor. Replace shock bushing at front. Check driver side window, it doesn't work right, it has new motor. No price or payment written on work order.
(04 - 11 - 00) $0275.08 Service station - Remove radiator, and send out for repair, re-install, and fill with coolant.
(08 - 31 - 99) $0903.53 Service station - Check air conditioning, not working. Replace rear window seal (this is where the rubber caulking was put in). Replace motor mounts. Replace throttle cable. Replace air conditioning pump.
(03 - 19 - 99) $0350.00 Service station - Rubber seal windshield (this is where the rubber caulking was put in). Check rack. Check transmission leak.
(10 - 03 - 98) $0058.50 Service station - Alignment preformed after new rack installed.
(10 - 02 - 98) $0700.00 Service station - New rack installed
Shutt, Rick
(09 - 10 - 98) $0215.00 Service station - Check horn. Check driver's side window, doesn't work. Check door lock. Repair door lock.
(08 - 12 - 98) $0135.00 Service station - Recharge air conditioning system. Install cooling fans, and one thermal switch.
(07 - 16 - 98) $0068.20 Service station - Passed smog inspection
